0.7-14 thermal power boiler

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

0.7-14 thermal power boiler have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


0.7-14 thermal power boiler.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
0.7-14 thermal power boiler 0.7-14 thermal power boiler 0.7-14 thermal power boiler

Contact Us-China Zozen Boiler Suppli

leave us message. Please feel free to fill in the following form or email us ([email protected]) to get product information,price,service and other supports.We will reply to you within 24 hours as soon as possible.Thank You!

lexie@zozen.com > Get A Quote >

Float Glass Kiln Waste Heat Boiler--Z

Waste gases leaving float glass furnace at temperature ranging from 450 to 540℃ have a high potential for heat recovery. ZBG developed float glass kiln waste heat boiler to fully recycle high temperature flue gas from glass kiln and further its waste heat utilization more than 70%.

lexie@zozen.com > Get A Quote >

DHL series biomass-fired steam boiler - Biomass-fire

The boiler adopts a unique water circulation structure, the drum is free from heat and the heated water flows in one direction. In the event of a power outage, the water system does not vaporize and the water circulation is safe and reliable.

lexie@zozen.com > Get A Quote >

CHAPTER 4 BEHAVIOUR OF REINFORCED CONCRETE CORRODED

thermal power plants. Its composition varies with the type of fuel burnt, load on boiler and type of separator etc. The carbon content in fly ash should be as low as possible whereas the silica content should be as high as possible. There are about 80 thermal power plants functioning in India generating 0 7 14 21 28 35 42 49 56 Age of

lexie@zozen.com > Get A Quote >

Energy Analysis of Supercritical Water and Ammonia (Kalin

energetic efficiency of thermal power plants, but due to the low temperature of the gas condenser and boiler which is 12% more than Rankine cycle efficiency in the same 13 343.6 1.01 2950

lexie@zozen.com > Get A Quote >

Compaction and strength characteristics of Lime activate

A very fine by-product generated through coal combustion process at thermal power plants is known as flyash and a part of ash falls down at the bottom of the boiler is known as bottom ash. These samples were cured under an average temperature of 28ºC with samples sealed in wax for curing periods of 0, 7, 14 and 28 days and the UCS values

lexie@zozen.com > Get A Quote >

Chapter 5 CHE Thermo Beaucage - University of Cincinna

power plants are based on modifications of the Rankine cycle, discussed below. Nevertheless, the The work done by the pump, the heat required, and the thermal efficiency; (c) The circulation rate to provide 1 MW net power output. Chapter 5 CHE Thermo Beaucage.pptx

lexie@zozen.com > Get A Quote >

China Boiler Machine, China Boiler Machine Manufacturer

China Boiler Machine, China Boiler Machine Suppliers and Manufacturers Directory - Source a Large Selection of Boiler Machine Products at rice mill boiler ,thermal …

lexie@zozen.com > Get A Quote >

Solar power in the United States - Wikiped

Solar power in the United States includes utility-scale solar power plants as well as local distributed generation, mostly from rooftop photovoltaics.As of the end of 2017, the United States had over 50 gigawatts (GW) of installed photovoltaic capacity. In the twelve months through December 2018, utility scale solar power generated 66.6 terawatt-hours (TWh), 1.66% of total U.S. electricity.

lexie@zozen.com > Get A Quote >

Thermal oil boiler- Zozen Boil

Zozen achieved 12,000 ton/hour manufacturing capacity of Industrial boiler which is listed on top of the boiler industry.

lexie@zozen.com > Get A Quote >

International Journal of ChemTech Research - sphinxsai.c

M.Sowrirajan et al /International Journal of ChemTech Research, 2017,10(2): 948-960.949 Fig. 1 Basic bead geometry Conduction heat transfer is the transfer of …

lexie@zozen.com > Get A Quote >