agricultural biomass boiler

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages

agricultural biomass boiler have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.

agricultural biomass boiler.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
agricultural biomass boiler agricultural biomass boiler agricultural biomass boiler

Small Biomass Boiler Technology - Ministry of

A high-efficiency biomass boiler has advantages, compared to traditional units, that can lead to significant savings. Table 1 compares several technologies, demonstrating that some high-efficiency equipment . > Get A Quote >

Biomass Power Plant | Boiler plants | Products Guide |

Biomass Power Plant Regenerative Energy Earth-friendly Energy Waste Recycling 60 Years of Boiler manufacturing Experience Regenerative Energy Plants continue to grow as long as existence of sun light, water and soil. Efficient > Get A Quote >

Agricultural Biomass for Combustion Ener

Agricultural Biomass for Combustion Energy Project to Commercialize Agricultural Biomass for Combustion Energy About the Steering Committee Working Group Reports Terms of Reference Biomass Forums Funding for > Get A Quote >

(PDF) The effect of halloysite additive on operation of

PDF | The paper presents results of investigations on using halloysite as an additive in biomass-fired boilers. It has been shown that in the case of a few different agricultural biomasses the halloysite addition increased the ash > Get A Quote >

Enertech Systems Industries, Inc. - Biomass Combi Boil

The Enertech Biomass Fired Combi Boiler is the ideal alternative to the high operating cost oil fired boilers. In areas where biomass fuels such as agricultural waste are available, the net savings from the lower fuel cost will enable > Get A Quote >

[Biomass Boiler Heating Fueled by Agricultural Wast

<1> MRV Demonstration Study (DS) using a Model Project 2012 Final Report [Biomass Boiler Heating Fueled by Agricultural Waste] (Implemented by Joint Venture of Mitsui Consultants and Japan Environmental Consultants) > Get A Quote >

Biomass Boiler | Boimass boiler Manufacture

We are one of the best biomass boiler manufacturer in Ghaziabad in which we manufacture other types of boiler also like gas boilers, gas fired boiler & more Biomass Boiler: Biomass Boiler: Energy solutions based on biomass > Get A Quote >

Installations | IEC Solutions - Biomass Companies

Biomass boilers are an efficient and highly versatile method of providing heat for any agricultural or commercial use, and RHI funding can offset the cost of the installation. At IEC Heat Solutions, our expertise and strength is in > Get A Quote >

Case Study – Agricultural Biomass – Trusted Ener

District heating system for a family business in Lincolnshire Incorporating a Dairy Farm, large family home and 6 cottages Providing hot water and heating for the properties and hot water for the milking parlour Wood Chip Biomass > Get A Quote >

Biomass Boilers | Hurst Boil

GO CARBON NEUTRAL BIOMASS BOILER SYSTEMS GO Carbon Neutral with a Hurst Biomass Boiler System Reduce Carbon, Reduce Emissions, Reduce Operating and Energy solutions based on biomass and bio-fuels > Get A Quote >


FOULING AND ITS MITIGATION IN PC BOILERS CO-FIRING FORESTRY AND AGRICULTURAL BIOMASS S. Kalisz1, Sz. Ciukaj1, M. Tymoszuk1 and H. Kubiczek2 1 Silesian University of Technology Institute of Power > Get A Quote >