Product thermal capacity: 4-35 t/h
Working pressure: 1.0-2.5 MPA
Outlet temperature: 184-350 ℃
Available fuel: natural gas, coke oven gas, bio-gas，liquid propane gas, diesel, heavy oil, light oil, crude oil
Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries
fire tube and water tube boilers have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.
fire tube and water tube boilers.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).
Jun 05, 2018 · Comparison between Fire Tube and Water Tube Boiler can be done in 14 aspects. Those aspects are operating pressure, passage of material type in tubes, rate of steam generation, handling of load fluctuation, floor area requirement, efficiency, operator skills, design, maintenance cost are listed below in the tabular firstname.lastname@example.org > Get A Quote >
A fire-tube boiler differs from a water tube boiler, and is a type of boiler in which hot gases from a fire pass through one or more tubes running through a sealed container of water.The heat of the gases is transferred through the walls of the tubes by thermal conduction, heating the water …email@example.com > Get A Quote >
Dec 07, 2016 · Water Tube Boilers. Unlike fire tube boiler, where the hot gas is circulated through tubes to heat water in a tank, water tube boilers involve running water through tubes surrounded by a heated tank. These types of boiler are generally considered safer than fire tube designs and typically require less frequent firstname.lastname@example.org > Get A Quote >
Firetube vs Watertube Boilers: a Comparison. Two primary boiler types, the firetube boiler and the watertube boiler, are essentially opposite in design. The firetube boiler passes combustion gas inside a series of tubes surrounded by water in a vessel to produce steam, while a watertube instead sends water through a series of email@example.com > Get A Quote >
Apr 23, 2016 · The difference between fire tube boiler and water tube boiler can be done on various points. These points includes types of fluid flows within the tubes, steam generation rate, floor area required for the steam generation, transportation, efficiency, fluctuating loads, operating cost etc. the knowledge of the difference about these two boiler is very firstname.lastname@example.org > Get A Quote >
Mar 19, 2016 · The main difference between fire tube and water tube is that in fire tube boiler the flue gases flow in the tubes and water flows from the shell and in water tube boiler, water flows from the tubes and the flue gases from the shell or passes over the tubes. This is the key difference between these email@example.com > Get A Quote >
What is a Fire tube boiler? The universal type of steam boilers is the smoke tube or fire tube boiler where the heat and gases of combustion (from furnace) pass through tubes that are enclosed by water. While in water tube boilers, water passes through tubes.Mostly used boiler in small and medium industries with different fuels and steam pressure firstname.lastname@example.org > Get A Quote >
A fire-tube boiler is a type of boiler in which hot gases pass from a fire through one or (many) more tubes running through a sealed container of water. The heat of the gases is transferred through the walls of the tubes by thermal conduction, heating the water and ultimately creating steam.. The fire-tube boiler developed as the third of the four major historical types of boilers: email@example.com > Get A Quote >
Fire Tube Boiler Construction and Working Principle of Fire Tube Boiler. The construction of a water tube boiler can be equipped with cylindrical shell, vertical, firebox in the base, space for water in the center segment, and space for steam in the higher segment. A fire-grate is located at the fire-box base as well as coal is fired-up on firstname.lastname@example.org > Get A Quote >