120 th Coal Fired CFB Boiler in Petrochemical Corporation

Industrial boilers

Product thermal capacity: 4-35 t/h

Working pressure: 1.0-2.5 MPA

Outlet temperature: 184-350 ℃

Available fuel: natural gas, coke oven gas, bio-gas,liquid propane gas, diesel, heavy oil, light oil, crude oil

Available industries: Petroleum, chemical, chemical fiber, pharmaceutical, textile printing and dyeing, building materials, wood processing, vegetable oil processing and other industries

  • Product introduction
  • Technical advantages
Introduction

120 th Coal Fired CFB Boiler in Petrochemical Corporation have a three-pass round coil structure. A conical coil is used for the effective protection of the furnace wall at the boiler end. This product is equipped with an advanced combustion device and is fully automated in operation. After the burner ignites the fuel, flame fills the round coil tubes and transfers heat by radiation through the tube wall (first pass). The high temperature flue gas gathers at the back door and then turns to the convection tubes section (second pass), where heat transfer takes place by convection. The flue gas gradually cools down here and flows to the front door, where it is reversed and goes into the third pass. After that, it enters into the chimney through the economizer and is released into the atmosphere.


120 th Coal Fired CFB Boiler in Petrochemical Corporation.This type of heater is delivered as a whole, and is installed on site, it only needs to connect thermal gas(oil) piping and electricity to start operation. The heater has four heating areas: furnace radiation heating area, the first convection tube bundle heating area, the second convection tube bundle heating area and economizer (waste heat boiler).

Digitized manufacture
  • The laying-off of steel tube adopts CNC 3D laser cutting machine.
  • The manufacture of round coil tube adopts CNC coil tube automatic production line. Once-forming and no need for plastic .
Full argon arc welding
  • The tube butt adopts argon arc welding technique and the seams will be done x ray real-time imaging, preventing unqualified seams from entering coil production line .
Easy operation
  • Heater is wholly assembled before delivery, it is easy for installation, debugging and operating.
  • Fully automatic operating, burning, liquid level of high level tank, outlet temperature and flow rate are adjusted automatically and self-protected.
  • The inlet and outlet with end flanges and flanged cover structure facilitate the installation and layout of tubeline in boiler house.
Less fuel consumption
  • Internal side adopts good insulation material, outside uses stainless steel plate, which can mostly reduce heat lost and make working environment better.
  • Multilayers closely spaced tube bundle and steel rod is used to seal and fix, completely eradicating short circuit of flue gas.
  • Before delivery, the residue moisture is removed completely, so the system draining period is reduced to 2 days from 12 days.
Safely operation
  • The inner coil tube has bigger flow rate, so it is more stable under high temperature operation.
  • Conical coil effectively protects the furnace wall at the end of heater and burner on the top.
120 th Coal Fired CFB Boiler in Petrochemical Corporation 120 th Coal Fired CFB Boiler in Petrochemical Corporation 120 th Coal Fired CFB Boiler in Petrochemical Corporation

Document - SEC.g

We also have entered into a natural gas supply agreement with Encore Energy for our long term natural gas needs, but this does not assure availability at all times. In addition, our current environmental permits limit the annual amount of natural gas that we may use in operating our gas-fired boiler.

lexie@zozen.com > Get A Quote >

Utilization of fly ash coming from a CFBC boiler co-firin

Utilization of fly ash coming from a CFBC boiler co-firing coal and petroleum coke in Portland cement Article (PDF Available) in Fuel 86(16):2625-2631 · November 2007 with 1,397 Reads

lexie@zozen.com > Get A Quote >

Control Techniques for Carbon Monoxide Emissions Fro

Control Techniques for Carbon Monoxide Emissions from Stationary Sources is one of a series of documents to be produced under the program established to carry out the responsi- bility for developing and distributing control technology information.

lexie@zozen.com > Get A Quote >

Current status of coal gasification - ScienceDire

As shown in Fig. 7.1, there is a wide range of coal gasification technologies being supplied in China by overseas vendors, and an increasing use of domestic technologies is under way.Different technology variants are in operation, entrained flow, fixed bed, slagging, transport, and fluidized bed. Chinese-developed systems include opposed multiburner (OMB) gasification and multicomponent slurry

lexie@zozen.com > Get A Quote >

Pima 16 by Pimagazine Asia - Iss

A large proportion of China’s coal has less than 18% volatile matterand of anthracite coal too.Anthracite coal is difficult to ignite in a PC boiler, and over 30% of coal reserves are low

lexie@zozen.com > Get A Quote >

Boiler Steam Cycles - emetreinta.

Fire-tube boiler - Wikipedia. A fire-tube boiler is a type of boiler in which hot gases pass from a fire through one or (many) more tubes running through a sealed container of water. The heat of the gases is transferred through the walls of the tubes by thermal conduction, …

lexie@zozen.com > Get A Quote >

carboncap-cleantech.c

FOREWORD Currently, over 50 percent of electricity in the U.S. is generated from coal. Given that coal reserves in the U.S. are estimated to meet our energy needs over the next 25

lexie@zozen.com > Get A Quote >

Boiler Tube (Environmental Management) Download

Find and compare a variety of on the world's largest environmental portal. View product and services catalogs, brochures, case studies, company news and more. …

lexie@zozen.com > Get A Quote >

zozen-boilers - Boiler Professional Manufacturing Expe

120 tons of fluidized bed steam boiler; 120 ton/h oil fired steam power plant boiler; 120 th Coal Fired CFB Boiler in Petrochemical Corporation; 120 t/h coal fired cfb boiler; 12.5bar coal fired steam boiler; 12.5 bar steam boiler; 12-100kg/h capacity mini electric steam generator; 12 volt push button switch; 12 tons of waste heat boiler

lexie@zozen.com > Get A Quote >

Carbon capture and storage update - Energy & Environmenta

Seven prototype systems have been operated at 10 to 33 MW with coal-fired flue gas and compression of the CO 2. There are no larger plants operating on coal-fired gas, but one is under construction at 120 MW and another eight plants at 140 to 765 MW in various states …

lexie@zozen.com > Get A Quote >

ČKD Group je společenství inženýrských a výrobních fir

Fluid bed boiler for Lovochemie 17.09.2015. The final stage of supplying CKD Praha DIZ with a fluidized bed boiler with an output of 120 t/h from steam by burning brown coal, including transporting fuels, ash, fly ash and limestone flue gas cleaning is now in progress.

lexie@zozen.com > Get A Quote >